气体燃料气动火焰稳定器混合特性的初步研究

doi:10.13675/j.cnki. tjjs. 016

推进技术 ›› 2019, Vol. 40 ›› Issue (12): 2775-2782.DOI: 10.13675/j.cnki. tjjs. 016

气体燃料气动火焰稳定器混合特性的初步研究

李子万¹,申小明^2,3,袁怡祥^2,3,LVARSEGOV V¹,肖波^2,3

1.图波列夫喀山国立技术大学喷气发动机与动力装置系;2.中国科学院工程热物理研究所，北京 100190;3.中国科学院大学;工程科学学院，北京;100190

发布日期:2021-08-15
作者简介:李子万，博士生，研究领域为燃烧过程与燃烧室。E-mail：liziwan_11@163.com
基金资助:
国家自然科学基金（50876104;51676182）;中科院中俄合作交流课题 Y9290382W1国家自然科学基金（50876104；51676182）；中科院中俄合作交流课题（Y9290382W1）。

Preliminary Study on Mixing Characteristics of Gas Fuel Aerodynamic Flame Stabilizer

1.College of Jet Engines and Power Plants,Kazan National Research Technical University Named after A. N. Tupolev,Kazan 420111,Russia;2.Institute of Engineering Thermophysics,Chinese Academy of Sciences,Beijing 100190，China;3.School of Engineering Science,University of Chinese Academy of Sciences,Beijing 100190，China

Published:2021-08-15

摘要/Abstract

摘要： 为了克服航空发动机加力燃烧室传统钝体火焰稳定器存在的流阻较大、燃烧效率较低和红外辐射偏大的缺点，设计了一种气体燃料气动火焰稳定器，通过喷射气体燃料射流形成气动屏障来产生回流区从而稳定火焰，并采用数值模拟计算和实验测试的方法研究了气体燃料火焰稳定器的混合特性。数值模拟计算表明气动火焰稳定器掺混速度快，可在回流区内形成余气系数比较均匀的混合物,且回流区内余气系数分布随来流和射流的参数变化基本保持恒定不变，实验结果证实了数值模拟的结果，并表明采用气动火焰稳定器的燃烧效率较高，部分工况可达98%以上，可为加力燃烧室火焰稳定器的研究和设计提供参考和依据。

关键词: 航空发动机;气体燃料;气动火焰稳定器;余气系数;燃烧效率

Abstract: In order to overcome the shortcomings of the traditional bluff body flame stabilizer in the afterburner of the aero-engine, such as the high loss of total pressure, the low combustion efficiency and the high infrared radiation, a gas fuel aerodynamic flame stabilizer is designed, which generates an aerodynamic barrier by injecting a gas fuel jet, and forms a recirculation zone to stabilize the flame. In this article the mixing characteristics of the gas fuel aerodynamic flame stabilizer are studied by numerical simulation and experimental tests. The numerical simulation shows that the aerodynamic flame stabilizer has a fast mixing speed and can form a mixture with a substantially uniform fuel-gas distribution/air-fuel equivalence ratio in the recirculation zone, which does not change a lot with the parameters of air flow and fuel jet. The experimental results confirm the numerical simulation and it show that the combustion efficiency of the aerodynamic flame stabilizer is high enough, at some working conditions up to 98%. This shows a good application prospect in afterburner.

Key words: Aero engine;Gas fuel;Aerodynamic flame stabilizer;Air-fuel equivalence ratio;Combustion efficiency

李子万,申小明,袁怡祥,LVARSEGOV V,肖波. 气体燃料气动火焰稳定器混合特性的初步研究[J]. 推进技术, 2019, 40(12): 2775-2782.

LI Zi-wan¹,SHEN Xiao-ming^2,3,YUAN Yi-xiang^2,3,V L VARSEGOV¹,XIAO Bo^2,3. Preliminary Study on Mixing Characteristics of Gas Fuel Aerodynamic Flame Stabilizer[J]. Journal of Propulsion Technology, 2019, 40(12): 2775-2782.

参考文献

[1] 金莉，谭永华. 火焰稳定器综述[J]. 火箭推进，2006， 32(1): 30-34.
[2] 张孝春，孙雨超，刘涛. 先进加力燃烧室设计技术综述[J]. 航空发动机， 2014， 40(2): 24-30.
[3] 杜一庆. 高温、低阻、高效加力燃烧室火焰稳定器机理研究[D]. 武汉：华中科技大学， 2005.
[4] 明贵清，何家德，王月贵，等. 加力燃烧室模型试验研究[J]. 燃气涡轮试验与研究， 1999， 12(4): 35-39.
[5] 秦伟林，何小民，金义，等. 凹腔驻涡与支板稳焰组合加力燃烧室模型冷态流场试验[J]. 航空动力学报， 2011， 27(6): 1347-1354.
[6] Колесников А С， Пахольченко А А. Применение Газодинамической Стабилизации Пламени в Форса-жных Камерах Сгорания Авиационных Газотурбин-ных Двигателей[J]. Авиационная и Ракетно-Космическая Механика, 2017， 16(4): 128-135. (Kolesnikov A C， Paholichenko A A. The use of Gas-Dynamic Flame Stabilization in Afterburner of Aviation Gas Turbine Engines[J]. Aviation and Rocket-Space Technology, 2017， 16(4): 128-135.)
[7] Мухаметталеев Т Х， Мингазов Б Г. Исследование Газодинамической Стабилизации Пламени в Потоке на Встречной Закрученной Топливовоздушной Струе[С]. Казань: X Международная Научно-Мехническая Конференция-Процессы Горения， Теплообмена и Экология Тепловых Двигателей， 2017. (Mukhametaleev T H， Mingazov B G. Investigation of Gas-Dynamic Flame Stabilization in Stream on a Opposing Swirling Fuel-Air Jet[C]. Kazan: X International Scientific and Technical Conference-The Pprocesses of Combustion， Heat Transfer and Ecology of Heat Engines， 2017.)
[8] Демена А М. Разработка Методических Основ Газодинамической Стабилизации Фронта Пламени Поточных Камер Сгорания на Закрученных Высокоэнтальпийных Струях[С]. Рыбинск: Рыбин-ская Государственная Авиационная Технологическая Академия Uмени П.А. Соловьева， 2008. (Demena A M. Development of Methodological Foundations of Gas-Dynamic Flame Stabilization for Combustion Chambers on Swirling High-Enthalpy Jets[C]. Rybinsk: Rybinsk State Aviation Technological Academy Named after P.A. Solovyeva， 2008.)
[9] Schaffer A， Cambel A B. The Effect of an Opposing Jet on Flame Stability[J]. Jet Propulsion， 1955， 25(6):284-287.
[10] Cambel A B. A Review of Flame Stabilization by Means of Gaseous Jet[С]. Oxford: Combustion and Propulsion, Third AGARD Colloquium, 1958.
[11] Schaffer A， Cambel A B. Continued Investigations of the Opposing Jet Flameholder[J]. Jet Propulsion， 1956， 26(7): 576-578.
[12] Костерин В А. Расчёт Камеры Сгорания со Стабилизаторами Пламени Текст[R]. Горение в Потоке, 1970.
[13] Лебедев Б П， Костерин В А， Гордон М С， т и .д. Аэродинамическая Стабилизация Пламени в Форсажных Камерах ТРДФ[M]. Москва: Труды ЦИАМ， 1977.
[14] Ben-Yakar A， Hanson R K. Experimental Investigation of Flame-Holding Capability of a Transverse Hydrogen Jet in Supersonic Cross-Flow[C]. Pittsburgh: Twenty-Seventh International Symposium on Combustion， 1998.
[15] Belanger， Hornung H. Transverse Jet Mixing and Combustion Experiments in Hypervelocity Flows[J]. Journal of Propulsion and Power, 1996， 12(1): 86-192.
[16] Ben-Yakar A， Hanson R K. Ultra-Fast-Framing Schlieren System for Studies of the Time Evolution of Jets in Supersonic Crossflows[J]. Experiments in Fluids， 2002， 2(4): 56-63.
[17] 杨茂林，全中，白兴艳，等. 尾缘吹气火焰稳定器试验研究[J]. 航空动力学报， 1998， 13(2): 185-188.
[18] 岳连捷，熊建秋，樊维均，等. 尾缘吹气火焰稳定器燃烧性能研究[J]. 航空动力学报， 2001， 16(4):345-349.
[19] 岳连捷，杨茂林，刘宝杰，等. 尾缘吹气式火焰稳定器时均流场[J]. 推进技术， 2003， 24(6): 524-527.
[20] Варсегов В Л. Цзывань Л Ю. Расчетное Исследование Газодинамики Течения за Газодинамическим Стаби-лизатором Пламени[C]. Казань: XXIII ТУПОЛЕВ-СКИЕ ЧТЕНИЯ (школа молодых ученых)， 2017. (Varsegov V L， Li Ziwan， Yousef V M. Calculation Study of Gas Dynamics of the Flow Behind the Gas-Dynamic Flame Stabilizer[C]. Kazan: XXIII TUPOLEVSKIE LECTION (School of Young Scientists)， 2017.)
[21] 张松寿. 工程燃烧学[M]. 上海：上海交通大学出版社， 1987.
[22] 金如山. 航空燃气轮机燃烧室[M]. 北京：宇航出版社， 1988.

气体燃料气动火焰稳定器混合特性的初步研究

Preliminary Study on Mixing Characteristics of Gas Fuel Aerodynamic Flame Stabilizer

可视化

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 0

编辑推荐

Metrics

本文评价